Mostrar el registro sencillo del ítem
Effect of Diesel Oil and Mixture of Alcohol-Glycol Ether on Colombian Ultrafine Coal Cleaning Using a Test-Rig Closed-Loop Flotation Column
dc.contributor.author | Piñeres Mendoza, J. | |
dc.contributor.other | Barraza Burgos, J. | |
dc.contributor.other | Bellich Fernandez, S. | |
dc.date.accessioned | 2022-11-15T20:45:51Z | |
dc.date.available | 2022-11-15T20:45:51Z | |
dc.date.issued | 2021-07-19 | |
dc.date.submitted | 2020-06-13 | |
dc.identifier.citation | Piñeres, J., Barraza, J., and Bellich, S. (2022). Effect of Diesel Oil and Mixture of Alcohol-Glycol Ether on Colombian Ultrafine Coal Cleaning Using a Test-Rig Closed-Loop Flotation Column. Ingeniería e Investigación, 42(1), e88273. 10.15446/ing.investig.v42n1.88273 | spa |
dc.identifier.uri | https://hdl.handle.net/20.500.12834/872 | |
dc.description.abstract | A test-rig closed-loop flotation column was used to observe the effect of diesel oil (collector) and Flomin F-425 (frother) on mass yield and ash content for two Colombian coals: Caypa (northern zone) and Guachinte (southwestern zone). The coal samples of less than 38 μm (-400 M) were processed in a collector concentration range of 0,32 to 1,60 kg/ton of coal, as well as a frother concentration range of 10 to 50 ppm. The response surface methodology was used for the experimental test runs. The results showed that the maximum mass yield obtained by Caypa coal was 98,39% at 1,28 kg of collector/ton of coal and 40 ppm of frother concentration, whereas Guachinte coal obtained a maximum mass yield of 94,71% at 0,96 kg of collector/ton of coal and 30 ppm of frother concentration. In general, for Caypa coal, the mass yield tends to increase (low ash removal) with the collector and frother concentration increase; while the mass yield tends to decrease (high ash removal) for Guachinte coal when the collector concentration increases (low ash removal) at high frother concentrations. It is worth highlighting that the ash content of 0,65% obtained for Caypa coal is the lowest value reported in the literature while employing a test-rig loop flotation column in a single stage, which is considered to be an ultra-clean coal obtained by a physical cleaning process. | spa |
dc.format.mimetype | application/pdf | spa |
dc.language.iso | eng | spa |
dc.rights.uri | http://creativecommons.org/licenses/by-nc/4.0/ | * |
dc.source | Ingeniería e Investigación | spa |
dc.title | Effect of Diesel Oil and Mixture of Alcohol-Glycol Ether on Colombian Ultrafine Coal Cleaning Using a Test-Rig Closed-Loop Flotation Column | spa |
dc.title.alternative | Efecto del diésel oil y la mezcla de alcohol-glicol-éter en la limpieza de carbón ultrafino colombiano utilizando una columna de flotación de prueba en bucle cerrado | spa |
dcterms.bibliographicCitation | Arnold, B. and Aplan, F. (1986a). The effects of clays slimes on coal flotation, part 1: the nature of the clay. International Journal of Mineral Processing, 17(3-4), 225-242. 10.1016/0301-7516(86)90058-X | spa |
dcterms.bibliographicCitation | Arnold, B. and Aplan, F. (1986b). The effects of clays slimes on coal flotation, part 2: The role of water quality. International Journal of Mineral Processing, 17(3-4), 243-260. 10.1016/0301-7516(86)90059-1 | spa |
dcterms.bibliographicCitation | Bellich, S. (2016). Diseño y montaje de una columna de flotación a escala de laboratorio para la remoción de la materia mineral presente en carbones térmicos [Undergraduate thesis, Universidad del Atlántico, Barranquilla, Colombia]. http://biblioteca.uniatlantico.edu.co/cgi-bin/koha/opac -detail.pl?biblionumber=78734 | spa |
dcterms.bibliographicCitation | Brady, G., Gauger, A. (1940). Properties of coal surface. Industrial and Engineering Chemistry, 32(12), 1599-1604. 10.1021/ie50372a019 | spa |
dcterms.bibliographicCitation | Cooke, N., Maynard, F., and Gaikwad, R. (1986). FT-i.r spectroscopic analysis of coals and coals extracts. Fuel, 65(9), 1254-1260. 10.1016/0016-2361(86)90238-3 | spa |
dcterms.bibliographicCitation | Dobby, G. and Finch, J. (1986). Flotation column scale-up and modelling. CIM Bulletin, 79(891), 89-96. https://store.ci m.org/en/flotation-column-scale-up-and-modelling | spa |
dcterms.bibliographicCitation | Finch, J., Nesset, J., Acuña, C. (2008). Role of frother on bubble production and behaviour in flotation. Minerals Engineering, 21(12-14), 949-957. 10.1016/j.mineng.2008.04.006 | spa |
dcterms.bibliographicCitation | Fuerstenau, D. W. (1982). Adsorption of frother at coal/water interfaces. Colloid and Surface, 4(3), 213–227. 10.1016/0166-6622(82)80019-X | spa |
dcterms.bibliographicCitation | Fuerstenau, D. W., Rosenbaum, J., and Laskowski, J. (1983). Effect of surface functional groups on the flotation of coal. Colloid and Surface, 8(2), 153-173. 10.1016/0166- 6622(83)80082-1 | spa |
dcterms.bibliographicCitation | Gupta, A., Banerjee, P., and Mishra, A. (2009). Influence of chemical parameters on selectivity and recovery of fine coal through flotation. International Journal of Mineral Processing, 92(1-2), 1-6. 10.1016/j.minpro.2009.02.001 | spa |
dcterms.bibliographicCitation | Gutiérrez, J., Purcell, J., and Aplan F. (1984). Estimating the hydrophobicity of coal. Colloids and Surface, 12, 1-25. 10.1016/0166-6622(84)80086-4 | spa |
dcterms.bibliographicCitation | Hangil, P., Junyu, W., and Liguang, W. (2016). A comparative study of methyl cyclohexanemethanol and methyl isobutyl carbinol as frother for coal flotation. International Journal of Mineral Processing, 155, 32-44. 10.1016/j.minpro.2016.08.006 | spa |
dcterms.bibliographicCitation | Hicks, D. (1982). Fundamental concepts in the design of experiments. Saunders Collage Publishing. | spa |
dcterms.bibliographicCitation | Honaker, R., Monhanty, M., and Crelling J. (1996). Coal maceral separation using column flotation. Minerals Engi | spa |
dcterms.bibliographicCitation | Jia, R., Harris, G., and Fuerstenau, D. W. (2002). Chemical reagents for enhanced coal flotation. International Journal of Coal Preparation and Utilization, 22(3), 123-149. 10.1080/07349340213847 | spa |
dcterms.bibliographicCitation | Leonard, J. and Hardinge, B. (1991). Coal Preparation. Society for Mining, Metallurgy and Exploration, Inc. | spa |
dcterms.bibliographicCitation | Montgomery, D. (2013). Design and Analysis of Experiments. John Wiley & Sons. | spa |
dcterms.bibliographicCitation | Peng, Y., Liang, L., Tan, J., Sha, J., and Xie, G. (2015). Effect of flotation reagent adsorption by different ultra-fine coal particles on coal flotation. International Journal Mineral Processing, 142, 17-21. 10.1016/j.minpro.2014.12.005 | spa |
dcterms.bibliographicCitation | Piñeres, J. and Barraza, J. (2011). Energy barrier of aggregates coal particle–bubble through the extended DLVO theory. International Journal of Mineral Processing, 100(1-2), 14- 20. 10.1016/j.minpro.2011.04.007 | spa |
dcterms.bibliographicCitation | Piñeres, J. and Barraza, J. (2012). Effect of pH, air velocity and frother concentration on combustible recovery, ash and sulphur rejection using column flotation. Fuel Processing Technology, 97, 30-37. 10.1016/j.fuproc.2012.01.004 | spa |
dcterms.bibliographicCitation | Piñeres, J., Mendoza, M., Téllez, M., and Jiménez, F. (2019). Level control loop design for a test-rig flotation column. Journal of Physics: Conference Series, 1219, 012014. 10.1088/1742-6596/1219/1/012014 | spa |
dcterms.bibliographicCitation | Polat, M., Polat, H., and Chander, S. (2003). Physical and chemical interactions in coal flotation. International Journal of Mineral Processing, 72(1-4), 199-213. 10.1016/S0301- 7516(03)00099-1 | spa |
dcterms.bibliographicCitation | Sobkowiak, M., Reisser, E., Given, P., and Painter, P. (1984). Determination of aromatic and aliphatic CH groups in coal by FT-i.r. 1. Studies of coal extracts. Fuel, 63(9), 1245-1252. 10.1016/0016-2361(84)90433-2 | spa |
dcterms.bibliographicCitation | Solomon, P. and Carangelo, R. (1988). FT-i.r analysis of coal 2. Aliphatic and aromatic hydrogen concentration. Fuel, 67(7), 949-959. 10.1016/0016-2361(8)90095-6 | spa |
dcterms.bibliographicCitation | Shu, X., Wang, Z., and Xu, J. (2002). Separation and preparation of macerals in Shenfu coals by flotation. Fuel, 81(4), 495-501. 10.1016/S0016-2361(01)00106-5 | spa |
dcterms.bibliographicCitation | Wieslaw, S. (1994). New trends in coal preparation technologies and equipment. Gordon and Breach Publishers. | spa |
dcterms.bibliographicCitation | Yoon, R. (1993). Microbubble flotation. Minerals Engineering, 6(6), 619-630. 10.1016/0892-6875(93)90116-5 | spa |
datacite.rights | http://purl.org/coar/access_right/c_abf2 | spa |
oaire.resourcetype | http://purl.org/coar/resource_type/c_2df8fbb1 | spa |
oaire.version | http://purl.org/coar/version/c_970fb48d4fbd8a85 | spa |
dc.audience | Público general | spa |
dc.identifier.doi | 10.15446/ing.investig.v42n1.88273 | |
dc.identifier.instname | Universidad del Atlántico | spa |
dc.identifier.reponame | Repositorio Universidad del Atlántico | spa |
dc.identifier.url | https://www.scopus.com/record/display.uri?eid=2-s2.0-85112300338&doi=10.15446%2fing.investig.v42n1.88273&origin=inward&txGid=dc9fda69b2a67d890f1369b1bd2e566c | |
dc.rights.cc | Attribution-NonCommercial 4.0 International | * |
dc.subject.keywords | flotation column | spa |
dc.subject.keywords | Colombian coals | spa |
dc.subject.keywords | closed loop | spa |
dc.subject.keywords | experimental design | spa |
dc.type.driver | info:eu-repo/semantics/article | spa |
dc.type.hasVersion | info:eu-repo/semantics/publishedVersion | spa |
dc.type.spa | Artículo | spa |
dc.publisher.place | Barranquilla | spa |
dc.rights.accessRights | info:eu-repo/semantics/openAccess | spa |
dc.publisher.discipline | Ingeniería Mecánica | spa |
dc.publisher.sede | Sede Norte | spa |